0.4 Add 47 mm for each additional I/O Unit s. m is number of I/O Units.
Specification External pilot (SUP/EXH block assembly) q e r t w y u i o 10 Side ported q Series t Valve stations w Type 1 JSY1000 3 JSY3000 5 JSY5000 L1m: 34 cores L2m: 17 cores Symbol Stations Note 02 2 stations Double wiring*1 Symbol Stations Note 02 2 stations Double wiring*1 16 16 stations 02 2 stations Specified layout*2 (Up to 32 solenoids available) 08 8 stations 02 2 stations Specified
3 Port Solenoid Valve Reduced power consumption: 0.55 w [With power saving circuit] 1.55 w [Standard] 0.55 0.55 w 1.55 .55 w Series VP300 (Conventional: 2.0 W) With DC light M Built-in full-wave rectifier (AC) P Noise reduction Noise is considerably reduced by changing it to DC mode with a full-wave rectifier. Power consumption is reduced by power saving circuit.
Servo motor Driver Driver Servo motor Servo amplifier Servo amplifier U U U U V V M V M V W W W W Do not connect AC power supply directly to the servo motor. Otherwise, a fault may occur. Install a surge absorbing diode on the DC relay designed for control output signal in the specified direction.
Load proportion is ((load weight x 9.8)/theoretical force) x 100% Conditions of Speed Chart System Solenoid valve Speed controller Tubing diameter x Length Silencer A B C D E F G H I J K 10 x 1 m 12 x 1 m 12 x 1 m SGP15A x 1 m SGP15A x 1 m SGP20A x 1 m SGP25A x 1 m SGP25A x 1 m SGP32A x 1 m SGP40A x 1 m SGP50A x 1 m VEX VEX3 2-02 1 2 AS4000-02 AN200-02 AS420-03 AS420-04 AS420-04 AS500-06
Electrical entry G Body Coil voltage Lead wire length 0.6 m 5: Plug lead sub-plate 1 2 3 4 5 6 100 VAC (50/60 Hz) 200 VAC (50/60 Hz) 110 VAC (50/60 Hz) 220 VAC (50/60 Hz) 24 VDC 12 VDC Lead wire length 1.5 m Grommet H Function Nil Y(1) R(2) Standard type (1 W) Low wattage type (0.5 W) External pilot Seal 0 1 Metal seal Rubber seal Note 1) Note 2) Applicable to DC specifications.
Condition: Pressure 0.5MPa, Load 50%, Piping length 5m Effective area mm 2(Cv ) Cylinder speed (mm/s) 50 63 80 100 125 140 Bore size (mm) 160 180 200 250 300 Port size Rc(PT) 40 250 25(1.4) VEX312 -01, 02 500 750 02 ( 1 4) 60(3.3) 250 500 750 250 500 750 500 750 1000 500 750 1000 250 500 750 250 500 750 VEX332 -02, 03, 04 Body ported Base mounted 03 (3 8) 160(8.9) VEX350 -04, 06, 10 06 (3
VR VH Body ported single solenoid Foot bracket VFA3122 F 02 VHS Body ported For 30 type manifold VFA3 1 0 3 02 Base mounted For 40 type manifold VFA3 1 0 4 02 Port size For 50 type manifold VFA3 1 50 W/o sub-plate (Pilot port: Rc) Nil W/o sub-plate (Pilot port: Other than Rc) Thread type for pilot port 00 For 60, 61,70, 71 manifold VFA3 1 0 6 02 02 03 1 4 3 8 Nil 00F 00N 00T Rc G NPT NPTF
The unit used is [S/m], incorporating [S] (Siemens), the opposite of [] (resistance). At 25C, the electrical conductivity of theoretically 100% deionized water is 0.055 [S/m].
The unit used is [S/m], incorporating [S] (Siemens), the opposite of [] (resistance). At 25C, the electrical conductivity of theoretically 100% deionized water is 0.055 [S/m].
Unit/Specifications Air filter (w/auto-drain, w/manual drain) 5m Filtration Regulator 0.05 to 0.85MPa Set press.
050 Cable length Connector specifications Cable length 003 005 010 030 050 0.3 m 0.5 m 1 m 3 m 5 m Socket side: Straight Plug side: Straight 010 050 1 m 5 m SSPS Socket side: Angle Plug side: Angle SAPA Connector specifications S A Straight Angle Cable core wire colors Terminal no.
Connector entry direction D side U side Electrical entry External pilot supply port Indicator light IP65 compatible U0 U1 U2 U3 U side D0 D1 D2 D3 D side Without cable Cable length 1.5 m Cable length 3 m Cable length 5 m Kit F Kit F U0 U1 U2 D0 D1 D2 1 to 12 stations Cable length 0.6 m Cable length 1.5 m Cable length 3 m Kit L Kit L 1 to 12 stations Type of connection T1 S kit (Serial transmission
Conductive silicone (black w/mark) tl In$fllinhffimffi Pb""","t"'t W,,Umtmf*, t Uentical IyF Uacuum Entny: tll|ithout Bulfen Specif ications Verticaltype Male thread l Female tfrread ,a2:..-',iz g: .', ,T:;l6a NIsx0.8,Nr6x1 M 4 x 0 7 , M 5 x 0 . 8 [ 4 5 x 0 . 8 , M 6 x 1 M5x0.8,1V16x l,1/g s20 s32 M 6 x l , M B x 1 M5 x 0.8,N46 x 1.M8 x 1.25,1/s s40 o50 M 6 x 1 , [ , 1 8 x 1 M G x 1 , M 8
Conductive silicone (black w/mark) tl In$fllinhffimffi Pb""","t"'t W,,Umtmf*, t Uentical IyF Uacuum Entny: tll|ithout Bulfen Specif ications Verticaltype Male thread l Female tfrread ,a2:..-',iz g: .', ,T:;l6a NIsx0.8,Nr6x1 M 4 x 0 7 , M 5 x 0 . 8 [ 4 5 x 0 . 8 , M 6 x 1 M5x0.8,1V16x l,1/g s20 s32 M 6 x l , M B x 1 M5 x 0.8,N46 x 1.M8 x 1.25,1/s s40 o50 M 6 x 1 , [ , 1 8 x 1 M G x 1 , M 8
-15A VNH3 -20A VNH4 -25A A B A B A B A B 60 80 100 115 217 (219) 246.5 (248.5) 282 (284) 301 (303) 60 77 96 113 46 60 76 85 34 40 50 60 24 36 41 50 135 164.5 200 219 50 60 79 90 77 1 8 1 2 3 x 3 4 3 x 1 1 4 95.5 111 119 VNH VNH 1 4 VND Note) ( ): CE-compliant product (-Q) VCC Model J K L M N O P Q R S T U VNH1 -10A A B VNH2 -15A A B VNH3 -20A A B VNH4 -25A A B M5 x 0.8 depth 5.5 M6 x 1 depth
3 Auto switches Nil M L Z 0.5 m 1 m 3 m 5 m Nil M A B C E F G Without auto switch (without magnet) Without auto switch (with built-in magnet) Nil S 2 pcs. 1 pc. 0.5m (Nil), 1m (M), and 5m (Z) for D-M9mA will be produced on receipt of order. With auto switch Select a model, referring to the table Applicable Auto Switches below. The auto switches are included when shipped (unmounted).
Z S L, Z S Note ) PAX 1 1 4 1 2 PB AC Ordering example (Example) Series VXR21, Rc 3/4, 24 VDC, Conduit terminal (Part no.)
Rc 1/8 Body side VZA414-1P-01 VZA414-1P-02 VZA414-2P-01 VZA414-2P-02 VZA424-1P-01 VZA424-1P-02 VZA424-2P-01 VZA424-2P-02 Rc 1/8 Rc 1/4 Rc 1/8 Rc 1/4 Rc 1/8 Rc 1/4 Rc 1/8 Rc 1/4 M5 x 0.8 0.49 0.11 2.2 0.57 0.19 2.4 N.C. Sub-plate side M5 x 0.8 0.49 0.11 2.2 0.57 0.19 2.4 N.C. Body side M5 x 0.8 0.45 0.32 1.9 0.57 0.19 2.4 N.O. Sub-plate side M5 x 0.8 0.45 0.32 1.9 0.57 0.19 2.4 N.O.