Slide Tables MX Series

15 20 25 30 40 50 60 75 100 125 150 175 200 225 250 275 300 Standard Stroke (mm) Bore Size (mm) 6 8 10 12 16 20 25 MXH MXS MXQ MXF MXW MXP Dual Rods For Twice The Force The MXS, MXQ, and MXW use a twin bore design to double the actuation force while maintaining the single bore height.

Information

-03 ASG521F-03 ASG620F-04 ASG621F-04 Inlet pressure: 0.5 MPa Inlet pressure: 0.5 MPa 1000 25 15 Flow rate (l/min (ANR)) Flow rate (l/min (ANR)) 1500 Effective area (mm2) Effective area (mm2) 20 10, 12 10 08 1000 15 500 10 5 500 5 0 0 0 0 0 5 10 0 5 10 Number of needle rotations (turns) Number of needle rotations (turns) 2 Stainless Steel Speed Controller Series ASG Construction Elbow type

IC

VE 4 point preset output pressure Applicable in the programming function with up to 20 steps. 10 bit parallel input signal (maximum) Pressure can be set with 2 10 = 1024 steps. VY1 G Step 1 Step 2 Step 3 Step 4 . . . . . . . . . . . . .

PSE530/200

Internal data error. 16-3-10 10 Series PSE530/200 Multi-channel Controller/Pressure Sensor Operation 1: Initial Setting 1 Channel selection MPa kPa OUT1 OUT2 CH 1 2 3 4 CH2 CH3 CH4 CH1 PRESSURE ZSE ISE SET PSE SET button and hold for 2 seconds or longer.

IC

Time Zero span correction function Deviation of the zero span point of the sensor can be corrected. 10 bit parallel input Keylock function Up to 10 bits of parallel input is possible from PLC. Pressure can be set with 2 10 = 1024 steps. To prevent erroneous operation, operation on the key can be disabled.

ARJ1020F

VY1 How to Order G Port size (IN, OUT) PPA 1/8 (Male thread), M5 x 0.8 (Female thread) 1/8 (Female thread) IN OUT 01 AL ARJ 3 10 01 BG ARJ 3 10 F BG With One-touch fitting 04 01 Option Body size 0.7 MPa setting (Standard) 0.2 MPa setting (1) Nil 1 S Model With seal Relieving type 10 Note 1) Compared with standard specifications, its adjusting spring has been only changed for 0.2 MPa.

SYJA3000

-M3 X 0.5 (Piping port) 33 36 (Non-locking) Manual override B P R R 7 7 SlA 36 2 35 7 13.5 28.5 15 A 21 R2 P R1 VlA 13 1 (Bleed port) 11 10 4 15 10 10 5-M5 X 0.8 (Piping port) 8.2 14 14 15 Bracket VM/VR VH 2 position double: SYJA3220-M3(-F) 2 position double: SYJA3240-M5 10 9 36 7.1 2-M3 X 0.5 (Pilot port) 10 1.8 4 A B (Mounting holes) 3.2 21.5 1.5 22 7 8.2 2.5 (Mounting holes for manifold

SI unit for DeviceNet ®

No.EX-OMN0013-I PRODUCT NAME SI unit for DeviceNet MODEL / Series / Product Number EX260-SDN# Table of Contents Safety Instructions 2 Model Indication and How to Order 8 Summary of Product elements 9 Installation and Wiring 10 Installation 10 Wiring 11 LED Indication and Settings 15 DeviceNet Objects 20 Troubleshooting and Maintenance 28 Specification 33 Specifications 33 Dimensions 35 Accessories

Self-seal Fittings Series KC

Nylon Urethane Effective orifice(mm 2) Weight (g) T (M) L Mounting hole M1 M2 KCE04-00 KCE06-00 KCE08-00 KCE10-00 KCE12-00 4 6 8 10 12 M12 1 M14 1 M16 1 M20 1 M22 1 14 42 13 15 17 21 23 18 19 21.5 24 25.5 16 17 18.5 21 22 21 30 39 84 115 2.6 6.8 13.1 20.4 30.4 2.6 6.8 16.2 25.6 35.4 17 19 24 27 45.5 52.5 59.5 63.2 Bulkhead female union: KCE Thread Rc (PT) 4 6 8 10 12 Effective orifice(mm

Rubber Seal 5 Port Solenoid Valve Series SY3000/5000

Symbol Nil R S RS Specifications Internal pilot specification External pilot specification Internal pilot specification/Built-in silencer External pilot specification/Built-in silencer Mounting position Symbol Applicable stations B 2 to 16 stations 2 to 10 stations 2 to 10 stations D U D side U side Both sides M Special specifications Indicate special specifications separately on a manifold

Rubber Seal 5 Port Solenoid Valve Series SX3000/5000

stations : W = 26n + 172 11 to 16 stations: W = 26n + 199 Note 3) SX3000 Weight W (g) n: Stations Lubrication Not required Unrestricted 150/30 Dust proof 2 to 10 stations : W = 54n + 227 11 to 16 stations: W = 54n + 264 SX5000 Mounting orientation Impact/Vibration resistance m/s Note) Note 1) Available with up to 16 solenoids.

PROFINET Compatible Fieldbus System

Fault No. 10 Fault Possible cause Investigation method Countermeasures Tighten the branch cable connection. (if there is a broken wire, replace the cable) Input unit PWR LED is OFF. Power supply for input and control: 24 VDC 10% Check the branch cable connections and check for broken wires.

Electronic Pressure Switch Series (Separate Type)

4 inputs 1 input Calibration method Push-button calibration Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com 0.1 to 1 MPa 10 to 101 kPa 100 to 100 kPa 10 to 100 kPa 50 to 500 kPa 0.1 to 1 MPa 10 to 101 kPa 101 to 101 kPa 10 to 100 kPa Set pressure range 0.2 to 2 kPa

Series CG1-Z 10-/11- ø20, ø25, ø32, ø40, ø50, ø63, ø80, ø100 21-/22- Air Cylinder: Double acting, Single rod

Model Auto switch mounting Cushion Rubber Bore size (mm) Port size Lubrication Action Standard stroke Note 2) (mm) Long stroke (mm) Note 1) Note 2) Model Air 10-/21-CG120 10-/21-CG125 10-/21-CG132 10-/21-CG140 10-/21-CG150 10-/21-CG163 10-/21-CG180 10-/21-CG1100 11-/22-CG120 11-/22-CG125 11-/22-CG132 11-/22-CG140 11-/22-CG150 11-/22-CG163 11-/22-CG180 11-/22-CG1100 20 25 32 40 50 63 80 100

LECA6_C

(P.48) 5() ()() () 6 10 - 3. 3.1.

Series MHR3 11- 3 Finger Rotary Actuated Air Gripper 22- Size: 10, 15

Applicable load Type 2-wire 3-wire Solid state auto switch Auto switch model D-M9B(V) D-M9N(V) Load voltage 24 VDC (10 to 28 VDC) 28 VDC or less 5 to 30 mA 50 mA or less Load current range Indicator light Yes Yes 24 VDC relay, PLC PLC: Programmable Logic Controller Refer to page 946 for the applicable auto switch list.

PF2A

How to Order Integrated Display Type M PF2A7 10 01 27 Flow rate range 1 to 10 l/min 5 to 50 l/min 10 to 100 l/min 20 to 200 l/min 50 to 500 l/min 10 50 11 21 51 Thread type Unit specification Nil M With unit switching function Fixed SI unit Note) Nil N F Lead wire (Refer to page 35.)

0.01

See Specific Product Precautions. 0.2 GD 0 0 10 20 30 40 50 Operating temperature (C) Port size Model Rated flow (L/min (ANR)) Note 1) Weight 60 80 100 100 100 100 300 400 500 500 35 g 35 g 35 g 35 g 60 g 150 g 190 g 190 g 190 g 260 g 4 (One-touch fittings) 6 (One-touch fittings) 8 (One-touch fittings) Rc, NPT, G 1/4 Rc, NPT, G 1/4 Rc, NPT, G 1/4 8 (One-touch fittings) 10 (One-touch fittings

Air preparation filter

Part name (8) (7) (1) Body (2) Element (1) (3) Bowl (4) Auto drain (5) Flange (5) (6) Stopper (7) Element service indicator (8) Bracket (9) Drain port spacer (6) (10) Drain cock (2) (3) (4) (9) (10) Options and spare parts No.

Soft Start-up Valve AV2000/3000/4000/5000

M6 x 1 Depth 7.5 39 50 0 77 74 59 155 128 143 3/4, 1 74 46 06 10 06 10 90 M6 x 1 Depth 7.5 39 50 0 77 74 59 175 128 3/4, 1 46 06 10 107 06 10 94 M6 x 1 Depth 7.5 39 50 0 77 74 59 175 128 3/4, 1 46 06 10 111 5 Soft Start-up Valve AV2000/3000/4000/5000 Modular F.R.L.