Compact Cylinder

140 160 45 50 55 60 65 70 75 80 85 90 55 60 65 70 75 80 85 90 95 100 110 130 150 C(D)55B20-5 -10 -15 -20 -25 -30 -35 -40 -45 -50 -60 -80 -100 -125 -150 C(D)55B25-5 -10 -15 -20 -25 -30 -35 -40 -45 -50 -60 -80 -100 -125 -150 C(D)55B80-10 -15 -20 -25 -30 -35 -40 -45 -50 -60 -80 -100 C(D)55B40-5 -10 -15 -20 -25 -30 -35 -40 -45 -50 -60 -80 -100 -125 -150 C(D)55B50-5 -10 -15 -20 -25 -30 -35 -40

Electric Actuator with Integrated Guide

40 2 x n2-M2.6 x 0.45 thread to 4.5 (Same pos. on opposite) 4-C3 11.5 A 42.5 32.5 5 4 1 8 5.8 3.3 Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com A B/2 in case of 500 to 600 mm strokes 22.5 19 B: Stroke + 75 10 19 Stroke + 95 64 Motor unit2 D section detail (Sensor

•

-Pad Type ~ Type 2 4 -' 6 8 10 1316 20 25 32 40 50 .

VQZ1000/2000/3000

Body Ported Bore size Series CJ2 Pressure 0.5 MPa Load factor 50% Stroke 60 mm Series CM2 Pressure 0.5 MPa Load factor 50% Stroke 300 mm Series MB/CA1 Pressure 0.5 MPa Load factor 50% Stroke 500 mm Average speed (mm/s) Series 6 10 16 20 25 32 40 40 50 63 80 100 800 700 600 500 400 300 200 100 0 Perpendicular, upward actuation Horizontal actuation VQZ1121-C6 Courtesy of Steven Engineering,

Free Mount Cylinder Series CU

8 8 8 8 10 12 9 12 17 20 22 29 11 12 13 16 20 24 20.5 22 28 33 43.5 51.5 16 16 19 21.5 22 22.5 18 21 26 29 33 42 10 11 14 16 20 24 5 6 8 10 M3 x 0.5 M4 x 0.7 M5 x 0.8 M6 x 1.0 M8 x 1.25 M10 x 1.25 16.5 16.5 Note) 19 21.5 23 Without auto switch With auto switch Bore size (mm) 6 10 16 20 25 32 P Q QA R SA T W Y S 38 36 30 36 40 42 Z 75 79 79.5 93 105 121 S 38 36 40 46 50 52 Z 75 79 89.5 103

21

20 25 32 40 6.8 15 30 30 37 3.2 18.4 59 139 9 15 40 40 50 4 28 75 161 9 15 40 40 50 4 28 75 174 Use a thin wrench when tightening the piston rod.

Swivels

Pressure 50 45 40 3/8" 45 40 35 40 35 Pressure Drop (psid) 30 1" 3/4" 35 Torque (in-lbs) 30 25 30 1" 1/2" 25 1/4" 1/4" RPM 25 20 1/2" 3/8" 20 3/4" 20 15 3/4" 15 15 1/2" 3/8" 10 1" 10 10 2" 1/4" 5 5 5 1-1/2" 0 0 0 0 2000 1000 3000 4000 5000 1000 0 2000 3000 4000 5000 0 10 20 30 40 50 60 70 80 90 Pressure (PSI) Pressure (PSI) Flow (USGPM) Quick Coupling Division 8145 Lewis Road Minneapolis

MVGQ

In the case of MVGQM50-40 st, an interface of 10 mm wide is installed inside of the MVGQ50-50 st, and thus the full length dimension of the body is the same as 50 st. 20, 30, 40, 50, 75, 100 125, 150, 175, 200 25 M L MVGQ M L 32, 40 25, 50, 75, 100, 125, 150, 175, 200 MVGQ 50, 63 10-16-9 10 Series MVGQ Weight (kg) Standard stroke (mm) Bearing type Bore size (mm) Model The allowable lateral

CG5-S

6 33 M5 x 0.8 5.5 8 14 3.5 M10 x 1.25 29 1/8 9 83 13 32 10 24 to 300 22 19.5 17 20 32 12 18 12 40 6 38 M5 x 0.8 5.5 10 16 3.5 M10 x 1.25 35.5 1/8 11 85 15 40 10 24 to 500 30 27 19 26 40 16 19 13 50 8 47 M6 x 1.0 6 14 16 4 M14 x 1.5 44 1/8 11 93 15 50 14 40 to 600 35 32 27 32 50 20 21 14 58 11 58 M8 x 1.25 7 18 22 5.5 M18 x 1.5 55 1/4 15 21 109 63 14 40 to 600 35 32 27 38 60 20 21 14 58 11

SMC Pneumatic Clean Series

25, 50, 75, 100, 125, 150, 200 1/8 Relief type Vacuum suction type 25, 50, 75, 100, 125, 1/4 150, 200, 250, 300 3/8 1/2 25, 50, 75, 100, 125, 150, 200 Available Available (40 to 63) 11-/22-CG120 11-/22-CG125 11-/22-CG132 11-/22-CG140 11-/22-CG150 11-/22-CG163 11-/22-CG180 11-/22-CG1100 Non-lube Double acting, Available 20 25 32 40 50 63 80 100 single rod 1/8 25, 50, 75, 100, 125, 1/4 150

AC Servo Motor Driver (Network card type ）

It is over 40 Lower the ambient temperature of the servo motor has temperature. exceeded 40. servo motor 1 It is less than 40 Check (2). (2) Servo motor is Check the effective load ratio. The effective load ratio is high. Reduce the load or review the operation overloaded. pattern. The effective load ratio is small.

Dual Rod Cylinder/High Speed Specification Type Series CXS-XB19

Standard stroke (mm) 10, 20, 30, 40, 50 10, 15, 20, 25, 30, 35, 40, 45, 50, 60, 70, 75 Bore size (mm) Nil S 6 10 10, 15, 20, 25, 30, 35, 40, 45, 50, 60, 70, 75, 80, 90, 100 15, 20, 25, 32 Auto switch type Nil Without auto switch (built-in magnet) Note) Refer to the table below for auto switch part numbers. Applicable auto switches Load voltage Auto switch part no.

Series CG1-Z 10-/11- ø20, ø25, ø32, ø40, ø50, ø63, ø80, ø100 21-/22- Air Cylinder: Double acting, Single rod

, 200 20 25 32 40 50 63 80 100 20 25 32 40 50 63 80 100 1/8 Relief type Vacuum suction type 25, 50, 75, 100, 125, 1/4 150, 200, 250, 300 3/8 1/2 Non-lube Double acting, Up to 1500 25, 50, 75, 100, 125, 150, 200 Single rod (40 to 63) 1/8 25, 50, 75, 100, 125, 1/4 150, 200, 250, 300 3/8 1/2 Note 1) When exceeding the standard strokes above, the particle generation class may not be satisfied

Basic type / Direct mount type Series CY3B/CY3R

90 87 115 D10 12 M6 x 1.0 M14 x 1.5 Rc1/8 7 40 70 100 42 73 16.5 25.5 0.5 1 90 97 115 12 11.5 M8 x 1.25 M20 x 1.5 Rc1/8 8.7 40 75 122 50 91 18.5 28.5 0.5 1 110 119 138 -X 12 11.5 M8 x 1.25 M20 x 1.5 Rc1/4 8.7 65 105 145 64 99 20.5 35.5 1 1 120 142 155 Individual -X PA dimensions are for split from center.

Rotary Clamp Cylinders

to 63 only Replacement Parts: Seal Kit 32 40 MK2-40-PS 50 MK2-50-PS 63 MK2-63-PS Bore size (mm) Kit no.

Series SY 5 Port Rubber Seal Solenoid Valve High Capacity & Simple Choices

Base Mounted Type SY3000/5000/7000/9000 < >: Values with surge voltage suppressor 3 position closed centre/exhaust centre/pressure centre Grommet (G), (H): SY7 40(R)-Q 02 03 3 4 5 Scale: 35% G H SV SY SY SYJ SX VK VZ VF VFR VP7 VQC SQ VQ L type plug connector (L): SY7 40(R)-L-Q M type plug connector (M): SY7 40(R)-M-Q DIN terminal (D): SY7 40(R)-D-Q 02 03 3 4 5 3 4 5 02 03 02 03 3 4 5 VQ4

Compact Cylinder with Solenoid Valve/

, 45, 50, 75, 100 5, 10, 15, 20, 25, 30, 35 40, 45, 50, 75, 100 10, 15, 20, 25, 30, 35 40, 45, 50, 75, 100 10, 15, 20, 25, 30, 35 40, 45, 50, 75, 100 Surge voltage suppressor Diode (Non-polar: Varistor) 32 1 Indicator light LED Note) The S and Z types of surge voltage suppressor have an internal circuit allowing voltage drop, so use within the following allowable voltage range.

0.4

RD SD LRUN PW 93.5 116 B RATE 42 (35) 66 75 80 x 1 x 10 STATION NO.

Compact Cylinder with Air Cushion Series RQ

x 140L Mounting bolt size M5 x 65L x 70L x 75L x 85L x 95L x 120L x 145L M6 x 85L x 95L x 105L x 130L x 155L M8 x 90L x 100L x 110L x 135L x 160L M10 x 105L x 115L x 140L x 165L M10 x 120L x 130L x 155L x 180L R(D)QB20-15 -20 -25 -30 -40 -50 R(D)QB25-15 -20 -25 -30 -40 -50 R(D)QB32-20 -25 -30 -40 -50 -75 -100 R(D)QB40-20 -25 -30 -40 -50 -75 -100 R(D)QB50-30 -40 -50 -75 -100 R(D)QB63-30 -

MXF

F A A MX Lr MTS MXF16 Lr = 40 mm MY 0.20 0.07 0.07 CY 0.06 0.06 MXF16-75 Table displacement amount (mm) Table displacement amount (mm) Table displacement amount (mm) 0.16 MXF16-75 MXF16-75 MXF16-50 MXF16-30 0.05 0.05 MG Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com