VSA4

Long service life (Over 20 million cycles) VHS Max. operating pressure Pilot air pressure Ambient temperature and operating fluid temperature 1.0 MPa 0.1 to 1.0 MPa 10 to 60C (1) Impact/Vibration resistance (m/s2) (3) Lubrication Not required (2) Dustproof (Enclosure class 0) (4) 150/50 Enclosure Note 1) Use dry air to prevent condensation when operating at low temperature.

Electro-Pneumatic Positioner

Electro-Pneumatic Positioner How to Order Series IP8000/8100 IP8 0 0 0 000 Accessories Note 2) Type IP8000 has standard lever for stroke (10 to 85mm) Accessory for IP8000, 8100 small capacity actuator Nil A Note 3) None (Standard) 0.7 Output restriction with pilot valve 1.0 Output restriction with pilot valve Fork lever joint M Fork lever joint S For stroke 35 to 100mm with lever unit For

Large Size Vacuum Module: Series ZR

When suction port is opened further, suction flow moves to maximum value (Qmax), but vacuum pressure is near 0 (atmospheric pressure). Based on the above, when vacuum port (vacuum piping) has no leakage, vacuum pressure becomes maximum, and vacuum pressure decreases as leakage increases. When leakage value is the same as max. suction flow, vacuum pressure is near 0.

VXD21/22/23

PA IN PAX Solenoid coil PB Coil: Class B, Class H Rated voltage Model AC Standard Option 100 V, 200 V 48 V, 110 V, 220 V, 240 V Orifice size (mm) Model Port size 10 VXD2130 Rc 1 4, 3 8, 1 2 Rc 3 8, 1 2 Rc 3 4 DC 24 V 12 V 15 20 VXD214 VXD215 VXD226 VXD227 VXD238 VXD239 2 0 Standard Option 2 0 2 0 Rc 1 25 Material 2 0 32A 35 40A 40 2 0 Body Seal Brass/BC6, Stainless steel NBR, EPDM, FKM

VXZ

PAX 0 * PB / / / / 1 ! ! 17-3-61 2 The VX series will be revised shortly.

Hand Valve Series VH

0.7 0.8 0.9 0.9 Valve output pressure (MPa) Valve output pressure (MPa) Valve output pressure (MPa) 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.8 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.6 0.1 0.2 0.3 0.4 0.5 0.5 0.1 0.2 0.3 0.4 4000 6000 2000 200 400 600 800 1000 1000 2000 0 0 0 Flow rate (l/min)(ANR) Flow rate (l/min)(ANR) Flow rate (l/min)(ANR

VHS

Refer to p. 0-33 to 0-36 for Safety Instructions and common precautions. !0 !0 q ! !2 o u i !8 !6 !5 SlA Installation !3 !1 VlA 1(P) 2(A) 1(P) 2(A) Warning 1 When exhaust piping is connected to 3(R) port,effective area should be larger than the specified value mentioned in the table below. If it is smaller, air leakage will occur due to back pressure. y q w !4 SlA !7 !4 3(R) VlA !

ZMA

0 !1 !2 Part no. ZMA-FCB-0 ZMA0-0 ZM-SF ZM-SA SY114-5LOZ ZM-PV-0 Material Polyethylene Filter cover assembly Diffuser assembly Suction filter Silencer assembly Pilot valve Poppet valve assembly ZMA-T14CN (NPN) ZMA-T54CN (PNP) !3 Vacuum switch with timer NBR ZM-CV !4 Check valve ZMA-VC-1A !

lPSMt

Steel) IP300 . 1P3100 DIMENS'ONS MODEL 1P300 (Lever Type) tu O O r o r n N ^ " n o r7a <6,69) (LEVER TYPE) MODEL 1P3100 (Rotary Type) O N / (2) t/4 t,tPt J o o iJ5 [8 so]]NVOLUTE SPL]NE 5HA:T 4 9 2 1 [ 1 2 s 0 0 ] r r81 lJ oool oo zzo fr ool r 1 3 T H P U H O I E S \ \ o o L O O N 0 945 I 24 001 2 7ss [7r oo] N O World Wide Ag{C Support...

lPSMt

Steel) IP300 . 1P3100 DIMENS'ONS MODEL 1P300 (Lever Type) tu O O r o r n N ^ " n o r7a <6,69) (LEVER TYPE) MODEL 1P3100 (Rotary Type) O N / (2) t/4 t,tPt J o o iJ5 [8 so]]NVOLUTE SPL]NE 5HA:T 4 9 2 1 [ 1 2 s 0 0 ] r r81 lJ oool oo zzo fr ool r 1 3 T H P U H O I E S \ \ o o L O O N 0 945 I 24 001 2 7ss [7r oo] N O World Wide Ag{C Support...

2/3 Port Solenoid Valve for Chemicals

0 !2 !0 !2 !0 !1 !1 !1 y y y t t t u u i i u i o o !3 !3 o !3 r r r e e w w e w q !4 !4 q q !4 LVM115 Description No. Material Part list/LVM13R, 14R, 16R, 115 !2 !0 Plate 1 PEEK/PFA !1 Diaphragm assembly 2 EPDM/FKM/Kalrez Body 3 PBT Slide bush assembly 4 POM/Stainless steel y Armature assembly 5 Stainless steel/PBT Coil assembly 6 t Sleeve 7 Iron u Spacer 8 i !

17

9 @0 e #7 i !6 @5 #5 q #9 #4 !3 #2 !2 @1 !0 @2 @6 #6 #3 @8 #1 @4 o #8 !

4/5 Port Solenoid Valve Rubber Seal Series SYJ3000 For details about certified products conforming to international standards, visit us at www.smcworld.com.

(Type 20 Manifold) SYJ3 2 5 M 1 M3 0 Body ported Base mounted (4 port) 2 SYJ3 3 5 M 0 (Manifold use only) Base mounted (5 port) SYJ3 4 M 2 0 5 4 port Port size Coil specifications Manual override Nil Standard Nil: Non-locking push type Nil: Without sub-plate With power saving circuit T (24, 12 VDC only) Power saving circuit is not available in the case of W type.

Power Valve: Economy Valve Series VEX5

900 1000 700 600 500 400 300 200 100 0 E 800 900 1000 700 600 500 400 300 200 100 0 F 800 900 1000 700 600 500 400 300 200 100 0 G When the cylinder is extended, the speed controller is metered-out, is connected with the cylinder directly, and its needle is fully open.

Air Checker:

range 220n 0 psi (0 MPa) Vacuum adjustment 30 range 0 psi 14.5 psi 14.5 psi 65 psi/ 58 psi AIRCHECKER PS1000-R06L (0 kPa) + 13 (100 kPa) (0.1 MPa) (0.45 MPa/0.4 MPa) PS1000/1100 PS1200 (For vacuum) MADE IN JAPAN G Refer to Best Pneumatics No. 6 for Pressure Switch Precautions, and the Operation Manual on our website for Specific Product Precautions. 10 Specifications 30 Model PS1200 PS1000

PC Wiring System

Dimensions 10.5 10.5 178 (3.6) 1 C H C H R S 16.7 OUT IN AX/ 140A 28.3 0 45 4.1 53.5 5.1 (3.7) 55 1 1F 16 D 4 0 2 3 5 6 7 8 9 A B C E F 10 11 12 13 14 15 17 18 19 1A 1B 1C 1D 1E + + + + + + + + + + + + + + + + 4.5 5 5 Refer to page 50 in CAT.E02-20 for the junction cable part number.

LCD Readout Digital Pressure Switch Series ZSE3 (For Vacuum)/ISE3 (For Positive Pressure) For General Pneumatics Easy pressure setting with the digital display Can be integrated with a vacuum unit, Series ZX ZSE ISE ZSP PS ISA PSE IS ISG ZSM Built-in fail

to 101 kPa 0 to 98 kPa 0 to 0.98 MPa Operating pressure range Max. operating pressure 200 kPa (1) 1 MPa kPa MPa 1 1 0.01 Min. display unit Indicator light Frequency response (2) N: When Green LED (OUT1) or Red (OUT2) turns on 200 Hz Adjustable (Variable from 0) Fixed (3 digits) Hysteresis mode Window comparator mode (3) Hysteresis Fluid Temperature characteristics Repeatability Power supply

2-Color Display High Precision

ON OFF Time I Display unit switching function (F 0) Display units can be switched with this function.

AK1000

2P 3P 4P 4PL 5PC No code VS PK TF V3 1 2 10 40 -30 in.Hg to 30 psig -30 in.Hg to 100 psig 0 to 200 psig 0 to 1000 psig 0 to 4000 psig -0.1 to 0.2 MPa -0.1 to 0.7 MPa 0 to 1.5 MPa 0 to 7 MPa 0 to 28 MPa Refer to the following porting configurations.

Mechanically Jointed Rodless Cylinder with Protective Cover Slide Bearing Guide Type, Cam Follower Guide Type MY1  W Series ø 16, ø 20, ø 25, ø 32, ø 40, ø 50, ø 63

to 6 6 to 12 12 to 18 0 to 11.5 11.5 to 23 23 to 34.5 0 to 12 12 to 24 24 to 36 0 to 16 16 to 32 32 to 48 0 to 20 20 to 40 40 to 60 0 to 25 25 to 50 50 to 75 0 to 5.6 5.6 to 11.2 11.2 to 16.8 Without spacer Stroke adjustment range by intermediate fixing spacer (mm) MY2C With short spacer With long spacer MY2 H/HT Stroke adjustment range is applicable for one side when mounted on a cylinder